Drive DeVilbiss Neo – fault codes, parts & serial label
Typemid/boot (varies)
Years / revisionMS040–MS042
ControllerPG S-Drive CONFIRMED
Fault codes (12)
From the S-Drive code set. All S-Drive codes
| Code | Meaning | Checks |
|---|---|---|
| 1 flash | Low battery | Charge batteries; check battery leads and connections |
| 2 flashes | Motor disconnected | Check motor connector/wiring; check freewheel lever |
| 3 flashes | Motor wiring trip | Check motor wiring for shorts; Dealer test |
| 4 flashes | Freewheel switch trip (current list). Older Drive sheets: not used | Put freewheel lever back to drive; cycle key |
| 5 flashes | Not used | — |
| 6 flashes | Inhibit 2 active – charger connected or seat not in drive position | Unplug charger; check seat position and inhibit wiring |
| 7 flashes | Throttle trip | Release throttle, cycle key; check wig-wag pot and wiring; recalibrate |
| 8 flashes | Possible control system trip | Check all connections; cycle key; replace controller if persistent |
| 9 flashes | Solenoid (park) brake trip | Check brake connector and coil; check freewheel |
| 10 flashes | High battery voltage | Check battery connections; cycle key |
| Slow single blink (every 2.5s) | Sleep mode (not a fault) | Cycle key to wake |
| 8 flashes (after battery refit) | Battery initiation artefact (Drive note) | Switch key off and on again; normal operation should return |
Serial code label
No serial location data yet for this mobility scooter. Serial codes
Parts (33)
| Part | Part no. |
|---|---|
| Motor brush | L40900600020 |
| Motor brush cap | C09-005-02400 |
| Motor with EM brake | C09-040-02500 |
| EM brake | C09-040-02600 |
| Manual brake ass. | S35-026-00100 |
| Transaxle ass. | C09-040-02403 |
| 120AMP S Drive controller | S10-067-00200 |
| 50AMP circuit breaker | M41610606000 |
| Battery | 12V34AH |
| Battery lead red & black connector | C17-029-00200 |
| Throttle assembly | S12-045-00100 |
| Throttle pot only | S12-032-00100 |
| Speed pot | M41100300000 |
| Charging socket | C12-051-00200 |
| Tyre | C06-002-00100 |
| Inner tube | C06-002-00301 |
| Front wheel ass. | S05-040-00200 |
| Rear wheel ass. RH | S06-040-00200 |
| Rear wheel ass. LH w/brake drum | S06-026-00300 |
| Key switch | C18-001-01501 |
| Battery gauge | C11-033-00101 |
| Wiring ass | C18-036-01205 |
| Flasher relay | C12-001-10701 |
| Drive Neo 4 Magnetic Brake | |
| Magnetic Brake Drive Neo 8 | |
| Brush Cap for Drive Envoy / Neo Mobility Scooter | |
| Throttle Pot Assembly Drive Devilbiss Neo,Prism & Rio Mobility Scooters | |
| Wig Wag Lever Drive Prism & Neo Mk2 | |
| Front Wheel Assembly Drive Neo 8 | |
| Rear Left Wheel Assembly Drive Neo 8 | |
| Rear Right Wheel Assembly Drive Neo | |
| Drive Speed Potentiometer (speed Pot) | |
| Throttle Pot Assembly Drive Devilbiss Mobility Scooters Cranked |
Summarised from public manuals and supplier listings. Always check the product's own manual before any repair.